Lets take this opportunity to look at the fuse holders and
the circuits they protect.
FU-2, [No I'm not making this up, that's it's designation.] protects
the lift motor circuit.It is the fuse located on the outside of the
trio. It usually has a blue wire at the bottom of the fuse holder. THIS
IS THE ONLY LOCATION WHERE A 30A Slo-Blo® FUSE IS SPECIFIED.
FU-3, in the middle of the trio protects all the control circuits.That
includes all the contactor coils and the RTN circuit that consists of
the Seat Switch, the Brake Switch and so on.The Centrifugal Switch on
the traction motor is also in series with this downstream of CB-1.
Were I you, it is at the bottom of this fuse holder that I
would start my investigation.Using either a circuit breaker or an old
thermal turn signal flasher, replace the fuse to limit your melted lead
in a glass tube collection. <G>
Remove all the wires from the bottom of the fuse holder. Close the
Power Disconnect. No Dramatic Activity? Reconnect the wires, one at a
time with the PD open, the close it to observe the results. When you
hit the wire that elicits Dramatic Activity, now you can trace it
through. :)
FU-4,at the opposite end from FU-2 in the trio protects the lighting
circuit only.
Hope this gets you heading in the right direction.
RJ
paul mitchell2007 comcast net wrote:
Yes, the lift motor works after the 30A fuse opens. The lights
are also inoperable, and I have all the manuals. I'm taking the day
off tomorrow to work on it, and this will be the first real
concentrated effort I've had to diagnose what's going on. However,
being that this is my first foray into diagnosing electrical problems,
I was hoping to get some ideas where to start.
Thanks
--------------
Original message --------------
From: RJ Kanary <rjkanary nauticom net>
Does the lift motor still work after the 30A fuse opens? If it
does, it's a sure bet that it's NOT the lift fuse. :( Are the lights
inop also ? BTW, do you possess the Homeowner's Service Manual ?
RJ
paul mitchell2007 comcast net
wrote:
It's the 30 amp fuse that blows, but the lift motor works
fine. I checked each battery individually, but not in succession as
you suggest. I'll be sure to check that next. The gauges on the dash
do nothing; everything appears to be dead. The numbers on the side
panel are (nearest I can tell) 26AF12C and P24121, but I'm not sure if
these are the original panels or not, as they were screwed on, not
riveted.
--------------
Original message --------------
From: Jim Coate <jbc_lists_NO_REPLY coate org>
> Caution: late night ramblings as I should be in bed, but that
said...
>
> By (sleepy) memory, the 30 amp fuse is for the lift; the control
fuse
> and lights fuse are each 20 amps. Which fuse is it that blows?
>
> If you go through the battery pack with your meter, does each
battery
> add ~6 volts to the total? ie keep the black meter lead on the
most
> negative terminal (B5-) and move the red lead up one battery at a
time
> and should see 6, 12, 18, 24, 30 and 36 volts (or a little higher
if
> fully charged) as move from B5+ to B6+ to B4+ to B3+ to B1+ to
B2+. And
> yes, GE numbered the batteries in the most confusing way possib
le.
> Diagram here:
> http://electrictractorstore.com/index.php?m
ain_pa ge=page&id=8&chapter=10
>
> I'd ask what the gauges on the dash do, but if the fuse blows, the
meter
> may not do anything?
>
> As RJ said, knowing what model would help. If the GE tag went to
the
> scrap yard along with the original rusty side panels, we'll have
to get
> a few details to guess the model. First up would be the
approximate
> diameter of the drive motor? (this determines if perm magnet model
JA or
> sep-ex models CA-HA).
>
>
> paul mitchell2007 comcast net
wrote:
> >
> > My E12 looks brand new: 4 new tires, rusted metal replaced,
fresh paint,
> > and new decals. The only problem...it doesn't run!
> >
> > 1) When I engage the power disconnect, the 30A fuse blows.
>
>
>
> --
> Jim Coate, Spencertown, New York
>
> = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = =
> NOTE: Mail sent to the "NO_REPLY" address will *not* reach me.
> To send me a private message, please follow the directions here:
> http://www.coate.org/contact_jim/
> = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = = =
>
> 1998 Electric S-10, 1997 Solectria Force, 1970's Elec-Traks
> http://www.eeevee.com
>
> The Electric Tractor Store is now open!
> http://www.electrictractorstore.com
_______________________________________________
Elec-trak mailing list
Elec-trak cosmos phy tufts edu
https://cosmos.phy.tufts.edu/mailman/listinfo/elec-trak
|